Product ID:MAC'S BLACK TIRE PAINT CONCENTRATE
MSDS Date:05/31/1989
FSC:8010
NIIN:00F034306
MSDS Number: BTNHF

VALVOLINE OIL CO

3499 DABNEY DR
LEXINGTON, KY 40512
US

Emergency Phone: 1-800-ASHLAND

Info Phone: 606-264-7000

Cage: 72527

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

FUEL OIL, NO. 2

CAS: 68476-30-2

RTECS: LS8930000

Fraction By Weight: 1-5%

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 35-40%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

ASPHALT OXIDE *93-1*

CAS: 64742-93-4

Fraction By Weight: 55-60%

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
MODERATE IRRITATION/DERMATITIS. INHALATION: MAY CAUSE NASAL &
RESPIRATORY IRRITATION EFFECTS, DEATH. INGESTION: GI IRRITATION.
ASPIRATION INTO THE LUNGS CAN CAUSE CHEMIC AL PNEUMONITIS WHICH CAN
BE FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION/REDNESS/TEARING/BLURRED
VISION/DEFATTING/DIZZINESS/WEAKNESS/FATIGUE/NAUSEA/HEADACHE/VOMITIN
G/DIARRHEA

First Aid:SKIN: WASH AREA W/SOAP & WATER. EYES: FLUSH W/PLENTY OF
WATER. INGESTION: DON'T INDUCE VOMITING. KEEP PERSON WARM & QUIET.
ASPIRATION HAZARD. INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR
IF NECESS ARY. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point:120F-140F
Lower Limits:1.0
Extinguishing Media:REGULAR FOAM/CO2/DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE OPERATED IN
POSITIVE PRESSURE DEMAND MODE. WATER & FOAM MAY CAUSE FROTHING
BECOME VIOLENT & ENDANGER THE FIREFIGHTER.
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM, EVEN EMPTY, PRODUCT CAN IGNITE EXPLOSIVELY. VAPORS ARE >AIR &
MAY TRAVEL ALONG THE GROUND/MOVED BY SEE SUPP

Spill Release Procedures:SMALL: ABSORB ON PAPER/VERMICULITE/FLOOR
ABSORBENT/OTHER MATERIAL. LARGE: ELIMINATE IGNITION SOURCES.
EVACUATE AREA. STOP AT SOURCE & DIKE/PUMP INTO SALVAGE TANK.
REMAINING LIQUID MAY BE TAKEN UP W AB SORBENT MATERIAL & SHOVELED
INTO CONTAINERS. SUPP

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED. EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES,
OBSERVE ALL HAZARD PRECAUTIONS.

Respiratory Protection:USE NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR
WHERE EXPOSURE LIMITS HAVE EXCEEDED.
Ventilation:MECHANICAL (GENERAL) LOCAL EXHAUST
Protective Gloves:RESISTANT/NITRILE RUBBER
Eye Protection:CHEMICAL SPLASH GOGGLES, SAFETY GLASSES
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
UNUSUAL FIRE HAZARD CON'D: VENTILATION & IGNITE BY AN IGNITION SOURCE
DISTANT FROM HANDLING POINT. SPILL PROCEDURE CON'T: PREVENT RUN-OFF
TO SEWERS & OTHER BODIES OF WATER. NOTIFY AUTHORITIES.

Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:BLACK LIQUID SLURRY
Percent Volatiles by Volume:35-40

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT/FLAME/IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO, VARIOUS HYDROCARBONS

Waste Disposal Methods:SMALL: DEPOSIT IN A LANDFILL IN ACCORDANCE
W/LOCAL/STATE & FEDERAL REGULATIONS. LARGE: DESTROY BY LIQUID
INCINERATION IN ACCORDANCE W/LOCAL/STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.